Page 1 of 1

Fuel line diagram?

Posted: 20 Jun 2022, 17:49
by Jen-etc
Can anyone point me in the direction of a fuel line diagram please?
When I got the bike the carbs and tank we're all off the bike so I've got no point of reference to work from!

My googling efforts are proving fruitless, so I'm hoping you guys in the know might be able to inform me where I can find something that will help me connect all the fuel lines up again!

Please and thank you!

Re: Fuel line diagram?

Posted: 20 Jun 2022, 20:24
by Fishrider
Mines a 750, but I believe everything is quite similar. If you are strictly asking about fuel, then the fuel line is routed from the petcock to the center input on the carbs. I run my fuel line between the to closest carbs with a filter right underneath the carbs and a clear line connected from the filter to the main fuel input on the carbs. The smaller output on the petcock is the vacuum line that you can place on any of the open carb vacuum ports. I place my tube on the third port. The 2nd port is capped and the 1st and 4th ports are used by the two tubes with a T connector that connects to the air air valve switch. There are fuel bowl overflow tubes that are connected to drains that run out to the right side of the bike. These are located and the left and right of the fuel line on the carbs between carbs 1/2 and 3/4. There is another port on the right side underneath the tank that has a hose attached and runs along side the bowl drain hose. I'll see if I can't throw something together later if you still need it.

Re: Fuel line diagram?

Posted: 20 Jun 2022, 21:29
by Richard
Maybe this will help....

https://images.cmsnl.com/img/partslists ... 1_1ae7.gif

Not sure which type you have though...

Re: Fuel line diagram?

Posted: 20 Jun 2022, 21:35
by Fishrider
I found this pick I had laying around. Maybe it helps a bit.

Re: Fuel line diagram?

Posted: 21 Jun 2022, 10:30
by Jen-etc
This is all incredibly helpful, thank you!

Wish me luck!